From: otranto@puglia.com   
      
   In article <009063e5$0$15071$c3e8da3@news.astraweb.com>, Rastamon   
    wrote:   
      
   > "Otranto"  wrote in message   
   > news:100720090908001891%otranto@puglia.com...   
   > > In article <009d76b1$0$23727$c3e8da3@news.astraweb.com>, Rastamon   
   > >  wrote:   
   > >   
   > >> "Otranto"  wrote in message   
   > >> news:090720092244005901%otranto@puglia.com...   
   > >> >   
   > >> > Here's the scene: '94 Surf 3.0 SSR Limited. Ascending a long gentle   
   > >> > gradient at 60 mph - temperature normal. Background ticking noise   
   > >> > becomes evident, followed quickly by a huge explosion and steam issuing   
   > >> > from both sides of the hood. Both the spigot and cap blown off the top   
   > >> > of the radiator. Obvious fatal blow between a cylinder and the water   
   > >> > jacket.   
   > >> > Now in the repair shop with the head off. No sign of a significant   
   > >> > gasket leak but one cylinder has obvious evidence of water ingestion -   
   > >> > white deposits on piston, valves and manifolds.   
   > >> > What's happened? - any ideas? Has anyone had this happen?   
   > >>   
   > >> Is there any water in the oil? 3VZ-FE engine?   
   > >>   
   > >> A warped head may not show significant water leak. Use a stopper type   
   > >> (sandwich) gasket on the rebuild, is recommended.  Typically the leak   
   > >> occurs   
   > >> at the rear cylinder (closest to the firewall), on the drivers side (Left   
   > >> hand side, American).   
   > >>   
   > > Haven't seen any water in the oil. It's a KZN130 with 1KZ-TE engine.   
   > >   
   > > Numbering from the front, water has been entering #2 cylinder only -   
   > > evidence of slight gasket leak between #3 and 4   
   > >   
   > > (Engine has taken 'an extra turn' to start for some weeks, accompanied   
   > > by a jolt on firing up but no sign of higher water temp.)   
   > >   
   > > Engine would run after explosion but with water shooting from the top   
   > > of the rad to a height of about 6'.   
   >   
   > Did you notice any water or white smoke coming from the exhaust?   
   >   
   > I'm not too familiar with the 1KZ-TE, is that a Diesel engine?   
   >   
   There may have been exhaust emission but I didn't see it - it all   
   happened in the space of less than a minute.   
      
   Engine: yep - 3.0 liter turbocharged diesel. Fitted from about 94-97 to   
   the bigger-engined (KZN130) 'Surf' in Japan, Australia/NZ and   
   'Roadrunner' in the UK.   
      
   --- SoupGate-Win32 v1.05   
    * Origin: you cannot sedate... all the things you hate (1:229/2)